2014, № 10 (171)

Kalimullin R.F., Kazakov A.V. DETERMINATION OF RATIONAL CONDITIONS OF USE OF PRE-HEAT TREATMENT MEANS FOR CAR ENGINEThe article describes the main provisions of the development of calculation and experimental methods in evaluation of resource efficiency of the car engine start mode allowing to define ranges of its pre-starting temperatures under which we have minimal pre-heat treatment losses of technical and fuel and energy resources for a single start.Key words: start mode, car engine, heat treatment, lubricating process, resource efficiency.

Download

References:

1. Suranov, G.I. Minimization of Automotive Engine Wear When Start / G.I. Suranov. — М.: Kolos, 1982. — 143 p.

2. Kovalenko, S.Yu. Estimation Methods of Car Engines Adaptation to Start Mode / S.Yu. Kovalenko, A.V. Kazakov // Vestnik of Orenburg State University. — 2011. — № 10. — P. 186–192.

3. Estimation Methods of Work Modes of Car Engine According to the Criterion of Durability of Crankshaft Bearings / R.F. Kalimullin [et al.] // Saratov State Technical University Bulletin. — 2013. — № 1(69). — P. 216–222.

4. Transitional Lubricating Process in Main Bearings of Car Engines / N.N. Yakunin [et al.] // Book of Reference. Engineer Magazine. — 2002. — №7. — P. 14–20.

5. Yakunin, N.N. Calculating Estimation of Lubrication Conditions of Main Bearings of Car Engines / N.N. Yakunin, R.F. Kalimullin // Orenburg State University Vestnik. — 2000. — №1. — P. 54–58.

6. Yakunin, N.N. Upgrading of Run-in Quality Estimation Methods of Crankshaft Bearings of Car Engines / N.N. Yakunin, А.P. Phot, R.F. Kalimullin // Orenburg State University Bulletin, 2006. — № 9. — P. 335–342.

7. Kalimullin, R.F. Development of Diagnostic Software of Crankshaft Bearings of Car Engines / R.F. Kalimullin // Irkutsk State Technical University Bulletin. — 2012. — № 5 (64). — P. 101–108.

8. Kazakov, A.V. Pre-start Heating of Lubricating System of Car Engine / А.V. Kazakov, R.F. Kalimullin // Orenburg State University Bulletin. — 2013. — № 12. — P.219–225.

9. Bondarenko, Е.V. Estimation of Efficiency of Pre-start Heating of Car Engine Oil Filter / Е.V. Bondarenko, А.V. Kazakov, R.F. Kalimullin // Irkutsk State Technical University Bulletin. — 2014. — № 2 (85). — P. 153–160.

10. Device to Control Bearing State: pat. 66046 Rus. Federation: МПК G 01 M 13/04 / Kalimullin R.F., Kovalenko S.Yu., Tsybizov S.B., Yanuchkov M.R. applicant for a patent and patent holder Orenburg State University. — №2007112656/22; applic. 04.04.07; publ. 27.08.07. Bul. № 24. — 3 p: il.

About this article

Authors: Kalimullin R.F., Kazakov A.V.

Year: 2014

Editor-in-chief

Sergey Aleksandrovich
MIROSHNIKOV

© Электронное периодическое издание: ВЕСТНИК ОГУ on-line (VESTNIK OSU on-line), ISSN on-line 1814-6465
Зарегистрировано в Федеральной службе по надзору в сфере связи, информационных технологий и массовых коммуникаций
Свидетельство о регистрации СМИ: Эл № ФС77-37678 от 29 сентября 2009 г.
Учредитель: Оренбургский государственный университет (ОГУ)
Главный редактор: С.А. Мирошников
Адрес редакции: 460018, г. Оренбург, проспект Победы, д. 13, к. 2335
Тел./факс: (3532)37-27-78 E-mail: vestnik@mail.osu.ru