2014, № 10 (171)

Barylnikova E.P., Kovrikov I.T., Kovalenko S.Yu. RESOURCE INCREASE OF AUTOMOBILE ENGINES BY STABILIZATION OF A GREASING MODE OF THE CONNECTING-ROD BEARING IN OPERATIONIn work results of research of lubricant process in bearings of a cranked shaft of the engine KAMAZ are presented. Violation of continuity of an oil stream is established at operational the deterioration of the bearings reducing pressure in system of greasing less than 0,26 MPa. Application of the developed way of diagnosing and by its results of the precautionary repair consisting in replacement of inserts at run of 125 thousand km. allows to low a share of failures of bearings of cranked shaft of KAMAZ engines to 34 %.Key words: bearings of a cranked shaft, lubricant process, oil stream, deterioration.

Download

References:

1. Kulakov, A.T. Research of operating conditions of bearings of a cranked shaft of engine / A.T. Kulakov, A.A. Makushin, E.P. Barylnikova // Vestnik of the Orenburg state university. — 2011. — No.10. — P. 135–138.

2. Makushin, A.A. Installation for research of conditions of greasing of bearings of cranked shaft / A.A. Makushin, E.P. Barylnikova // Tractors and agricultural cars. — 2012. — No.12. — P. 38–40.

3. Makushin, A.A. Influence of operational factors on conditions of greasing of bearings of a cranked shaft of autotractor engines / A.A. Makushin, E.P. Barylnikova // Tractors and agricultural cars. — 2013. — No.5. — P. 33–36.

4. System of supply of lubricant in an internal combustion engine / A.S. Denisov, A.T. Kulakov, E.P. Barylnikova, N.V. Orlov. The decision on issue of the patent for the invention of 2.08.2013 according to the demand 2012130497/06(047898) of 17.07.2012.

5. Barylnikova, E.P. Resource increase of automobile engines by stabilization of a greasing mode of the connecting-rod bearing in operation: abstract dis. … Cand.Tech.Sci. / E.P. Barylnikova. — Orenburg: Regional public institution, 2013. — 18 p.

About this article

Authors: Barylnikova E.P., Kovrikov I.T., Kovalenko S.Yu.

Year: 2014

Editor-in-chief

Sergey Aleksandrovich
MIROSHNIKOV

© Электронное периодическое издание: ВЕСТНИК ОГУ on-line (VESTNIK OSU on-line), ISSN on-line 1814-6465
Зарегистрировано в Федеральной службе по надзору в сфере связи, информационных технологий и массовых коммуникаций
Свидетельство о регистрации СМИ: Эл № ФС77-37678 от 29 сентября 2009 г.
Учредитель: Оренбургский государственный университет (ОГУ)
Главный редактор: С.А. Мирошников
Адрес редакции: 460018, г. Оренбург, проспект Победы, д. 13, к. 2335
Тел./факс: (3532)37-27-78 E-mail: vestnik@mail.osu.ru